CHAPTER 1 INTRODUCTION - TM-55-1930-209-14P-13_18
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Deckhouse Roof
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Deckhouse - cont
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Voids - cont
CHAPTER 2 BRIDGE CRANE SYSTEM
Equipment specifications - TM-55-1930-209-14P-13_23
Equipment specifications - cont
Figure 2-1 . Bridge Crane
Figure 2-2. Bridge Crane Route Diagram (Typical Layout)
Items furnished - TM-55-1930-209-14P-13_27
Figure 2-3 . Hoisting Rigs and Lifting Slings
Figure 2-3 . Hoisting Rigs and Lifting Slings - cont
Section II. Description of operation - TM-55-1930-209-14P-13_30
Table 2-1 . Weights, Measurements, and Locations of Movable Equipment in Voids and Deckhouse
Figure 2-4 . Bridge Crane Jib Rail (Stowed Toward Aft)
Figure 2-5 . Bridge Crane Hand-Held Control
Figure 2-6 . Two-Ton Hoist Hand-Held Control
Using crossover for trolley transfer
Figure 2-7 . Bridge Crane Crossover Assembly - TM-55-1930-209-14P-13_36
Figure 2-7 . Bridge Crane Crossover Assembly - TM-55-1930-209-14P-13_37
Section IV. Maintenance instructions - TM-55-1930-209-14P-13_38
Maintenance procedures - TM-55-1930-209-14P-13_39
Table 2-2. Bridge Crane Troubleshooting
Table 2-2. Bridge Crane Troubleshooting (Continued)
5-ton geared trolley hoist
Test - TM-55-1930-209-14P-13_43
Cleaning and inspection - TM-55-1930-209-14P-13_44
Electrical test and repair
Electrical test and repair - cont
Bridge Crane Trolley Brake
Figure 2-10. Bridge Crane System Schematic - TM-55-1930-209-14P-13_48
Figure 2-10. Bridge Crane System Schematic - cont
Figure 2-10. Bridge Crane System Schematic - TM-55-1930-209-14P-13_50
Cleaning and inspection - TM-55-1930-209-14P-13_51
Administrative storage - TM-55-1930-209-14P-13_52
Section VII. Manufacturers' warranties/guarantees - TM-55-1930-209-14P-13_53
CHAPTER 3 BOW CRANE SYSTEM
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_55
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_56
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_57
Figure 3-4. Hydraulic Power Unit Motor Controller
v
Limitations
Tools and test equipment
Section III. Operating instructions - TM-55-1930-209-14P-13_62
Bow crane procedures for deploying workboat
Workboat recovery procedures
Figure 3-6. START/STOP Control Station and Anti-2-Block Control Box on Deskhouse Top
Figure 3-7. Bow Crane Base
Figure 3-8. Workboat Cradle Tie-Down with Ratchet
Bow crane shutdown procedures - TM-55-1930-209-14P-13_68
Maintenance instructions.
Maintenance procedures - TM-55-1930-209-14P-13_70
Bow crane system.
Cleaning and inspection - TM-55-1930-209-14P-13_72
Figure 3-10. Anti-2-Block Control Panel
Repair - TM-55-1930-209-14P-13_74
Cleaning and inspection - TM-55-1930-209-14P-13_75
Replacement - TM-55-1930-209-14P-13_76
Test and repair - TM-55-1930-209-14P-13_77
Replacement - TM-55-1930-209-14P-13_78
Figure 3-11. Hydraulic Power Unit Motor Controller Schematic
Hydraulic power unit
Replacement.
Section V. Storage - TM-55-1930-209-14P-13_82
Section VII. Manufacturers' warranties/guarantees - TM-55-1930-209-14P-13_83
CHAPTER 4 VOID 4 TROLLEY HOIST
Figure 4-1. Void 4 Trolley Hoist
Section III. Operating instructions - TM-55-1930-209-14P-13_86
Maintenance procedures - TM-55-1930-209-14P-13_87
Replacement - TM-55-1930-209-14P-13_88
Section V. Storage - TM-55-1930-209-14P-13_89
APPENDIX A. REFERENCE
APPENDIX A. REFERENCE - cont
APPENDIX B MANUFACTURERS' SERVICE MANUALS/INSTRUCTIONS - TM-55-1930-209-14P-13_94
HOW TO ORDER REPLACEMENT PARTS - TM-55-1930-209-14P-13_98
SPANMASTER REPLACEMENT PARTS MANUAL
RECOMMENDED PREVENTATIVE MAINTENANCE PROGRAM
Crane and Carrier Drive Machinery
OPERATION AND SAFETY RECOMMENDATIONS
TM-55-1930-209-14P-13_103
QUARTERLY INSPECTION AND SERVICE ROUTINE
SEMI-ANNUAL INSPECTION AND SERVICE ROUTINE
RECOMMENDED SPARE PARTS LIST FOR SPANMASTER EQUIPMENT
35-300 SERIES GEARCASE
CHANGE GEARS
CRANE DRIVE ASSEMBLY
END TRUCKS
END TRUCK ASSEMBLY 3400 LB. CAPACITY - HAND PROPELLED
END TRUCK ASSEMBLY 13,000 LB. CAPACITY -MOTOR DRIVEN
END TRUCK ASSEMBLY 31,000 LB. CAPACITY-MOTOR DRIVEN
TROLLEY ROCKER PRINCIPLE - TM-55-1930-209-14P-13_114
TROLLEY ROCKER PRINCIPLE - TM-55-1930-209-14P-13_115
WHEEL TROLLEY
TROLLEY TRACK FOR FESTOONE ELECTRIFICATION
ELECTRICAL CONTROL PARTS
SAMPLE BALLAST RESISTOR DIAGRAM
HORIZONTAL AND VERTICAL MOUNTING
CRANE INTERLOCK
INSTALLATION OF REEL
PARTS LIST - TM-55-1930-209-14P-13_123
POW-R-MITE 200a AND 300a
MAINSPRING AND CUP
DESCRIPTION - TM-55-1930-209-14P-13_126
MAINTENANCE AND SERVICE
Table 2. Parts List
BRAKE SPECIFICATIONS
Parts and Instruction Manual Low Headroom
DO'S AND DON'TS FOR SAFE OPERATION
INSTALLATION - TM-55-1930-209-14P-13_133
INSPECTION - TM-55-1930-209-14P-13_134
RECORD COPY
HOIST MAINTENANCE
Gear Cover Side Parts Service
LUBRICATION
Mechanism - Handwheel End - TM-55-1930-209-14P-13_139
Mechanism - Handwheel End - TM-55-1930-209-14P-13_140
Mechanism - Handwheel End - CONT - TM-55-1930-209-14P-13_141
Mechanism - Handwheel End - CONT - TM-55-1930-209-14P-13_142
Hoist Assembly
Hoist Assembly - cont - TM-55-1930-209-14P-13_144
Hoist Assembly - cont - TM-55-1930-209-14P-13_145
Hoist Assembly - cont - TM-55-1930-209-14P-13_146
Hoist Assembly - cont - TM-55-1930-209-14P-13_147
Hoist Assembly - cont - TM-55-1930-209-14P-13_148
Hoist Assembly - cont - TM-55-1930-209-14P-13_149
Bottom Block Assembly
Bottom Block Assembly - cont - TM-55-1930-209-14P-13_151
Bottom Block Assembly - cont - TM-55-1930-209-14P-13_152
Trolley Drive Assembly
INSTRUCTION, MAITENANCE and PARTS MAUAL
INSTRUCTION, MAITENANCE and PARTS MAUAL - CONT
FOREWORD
ATTACHING LOAD CHAIN
POWER SUPPLY AND ELECTRICAL CONNECTIONS
CHECKING LIMIT SWITCH OPERATION
FIGURE 5. SHORTENING CONTROL CORD
FIGURE 6. LOW HEADROOM LODESTAR TROLLEY
Enclosed Collectors and Wiring
Wheel Assembly
Track Clamp Assembly
Track Clamp Assembly - cont
IMPORTANT. NOTICE
Bulletin J CHESTER ZEPHYR LOW HEAD ROOM HOISTS
ZEPHYR LOW HEAD ROOM HOIST
FIGURE 10. ATTACHING CHAIN CONTAINER.
SECTION B - OPERATION
SECTION C- MAINTENANCE
TESTING - TM-55-1930-209-14P-13_175
Lodestar Protector
Figure 13. CUTTING LOAD CHAIN
Hoist Lubrication
Figure 14. ENCLOSED TYPE LIMIT SWITCHES
SECTION D - TROUBLE SHOOTING
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_181
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_182
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_183
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_184
Wiring Diagrams shown are representative
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_186
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_187
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_188
SECTION E - REPLACEMENT PARTS LIST
FIGURE 18. CENTRIFUGAL MECHANISM ASSEMBLY
Lodestar Hoist - exploded view - TM-55-1930-209-14P-13_191
Parts List - TM-55-1930-209-14P-13_192
Lodestar Hoist - exploded view - TM-55-1930-209-14P-13_193
Parts List - TM-55-1930-209-14P-13_194
CONTROL STATION
CONTROL STATION USED ON MODELS A THRU H, THREE PHASE AND SINGLE PHASE WITH CONTACTOR, AND MODELS J THRU RR, ALL VOLTAGES
CHAIN CONTAINER
LOW HAEDROOM LODESTAR TROLLEY
ENCLOSED CONDUCTOR SYSTEM CURRENT COLLECTORS
SECTION F-NON-CURRENT PARTS
SECTION F-NON-CURRENT PARTS - cont
Parts List MODELS J, L & R
Type AB CONTRACTOR - Parts List
PUSH BUTTONS SWITCHES
SERIES D PUSH BUTTONS STATION
SERIES E PUSH BUTTONS STATION
MOTOR DRIVEN TROLLEY
MOTOR DRIVEN TROLLEY - PARTS LIST
LOW HEADROOM LODESTAR TROLLEY
Adjustment of Open Type Limit Switch
CURRENT COLECTORS
COLLECTOR ASSEMBLY PARTS LIST
OPERATING AND USE OF THE CRANE
USE OF ACCESSORIES
PERIODIC MAINTENANCE INSTRUCTIONS
PILLAR AND BASE ASSEMBLY
OUTRIGGER RAMS ASSEMBLY
OUTRIGGER EXTENSION RAMS
OUTRIGGER RAMS
DEVIATOR AND DISTRIBUTO ASSEMBLY WITH DOUBLE CONTROLS
DISTRIBUTORS
PIPING FOR OUTRIGGER EXTENTION RAMS
PIPING FOR OUTRIGGER RAMS
PIPING FOR ROTATION
PIPING FOR ROTATION - CONT
EXTENSION BOOMS ASSEMBLY FOR FIO.2
EXTENSION BOOMS AND MAIN JIB ASSEMBLY FOR FIO.2
EXTENSION BOOMS ASSEMBLY FOR FIO.3
EXTENSION BOOMS AND MAIN JIB ASSEMBLY FOR FIO.3
DOUBLE EXTENSION RAM
TRIPLE EXTENSION RAM
PIPING FOR MAIN RAMS (TYPE A)
PIPING FOR MAIN RAMS (TYPE B)
PIPING FOR SECONDARY RAM
PIPING FOR BOOMS EXTENSION RAM
OIL TANK ASSEMBLY
RETURN PIPINGS ASSEMBLY
PILLAR AND BASE ASSEMBLY - CRANE WITH SEAT
DEVIATOR AND DISTRIBUTION ASSEMBLY - CRANE WITH SEAT
DISTRIBUTOR FOR OUTRIGGER - CRANE WITH SEAT
SEAT AND DISTRIBUTION ASSEMBLY ON PILLAR
PIPING FOR DISTRIBUTOR - CRANE WITH SEAT
EXTENSIONS M AND MN FOR FIO.3
EXTENSION MNP FOR FIO.3
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_257
CONTROL PANEL TERMINAL
ANTI - TWO - BLOCK
ANTI - TWO - BLOCK - CONT
INSTALLATION PROCEDURE
CHECKOUT PROCEDURE
BOOM NOSE CONNECTOR
SCHEMATIC DIAGRAM
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_269
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_270
Troubleshooting - TM-55-1930-209-14P-13_271
Troubleshooting - cont - TM-55-1930-209-14P-13_272
Troubleshooting - cont - TM-55-1930-209-14P-13_273
Troubleshooting - cont - TM-55-1930-209-14P-13_274
Troubleshooting - cont - TM-55-1930-209-14P-13_275
Troubleshooting - cont - TM-55-1930-209-14P-13_276
Troubleshooting - cont - TM-55-1930-209-14P-13_277
Troubleshooting - cont - TM-55-1930-209-14P-13_278
Troubleshooting - cont - TM-55-1930-209-14P-13_279
Troubleshooting - cont - TM-55-1930-209-14P-13_280
Troubleshooting - cont - TM-55-1930-209-14P-13_281
REPAIR PARTS LIST - TM-55-1930-209-14P-13_290
REPAIR PARTS LIST - TM-55-1930-209-14P-13_291
REPAIR PARTS LIST - TM-55-1930-209-14P-13_292
REPAIR PARTS LIST - TM-55-1930-209-14P-13_293
REPAIR PARTS LIST - TM-55-1930-209-14P-13_294
REPAIR PARTS LIST - TM-55-1930-209-14P-13_295
APPENDIX C Preventive maintenance checks and services (PMCS) - TM-55-1930-209-14P-13_296
Introduction to PMCS - TM-55-1930-209-14P-13_297
Handling equipment description
APPENDIX C Preventive maintenance checks and services (PMCS) - TM-55-1930-209-14P-13_299
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_300
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_301
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_302
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_303
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_304
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_305
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_306
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_307
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_308
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_309
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_310
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_311
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_312
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_313
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Deckhouse Roof
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Deckhouse - cont
Figure 1-1 . Major Components of ROWPU Barge Systems and Equipment - Voids - cont
CHAPTER 2 BRIDGE CRANE SYSTEM
Equipment specifications - TM-55-1930-209-14P-13_23
Equipment specifications - cont
Figure 2-1 . Bridge Crane
Figure 2-2. Bridge Crane Route Diagram (Typical Layout)
Items furnished - TM-55-1930-209-14P-13_27
Figure 2-3 . Hoisting Rigs and Lifting Slings
Figure 2-3 . Hoisting Rigs and Lifting Slings - cont
Section II. Description of operation - TM-55-1930-209-14P-13_30
Table 2-1 . Weights, Measurements, and Locations of Movable Equipment in Voids and Deckhouse
Figure 2-4 . Bridge Crane Jib Rail (Stowed Toward Aft)
Figure 2-5 . Bridge Crane Hand-Held Control
Figure 2-6 . Two-Ton Hoist Hand-Held Control
Using crossover for trolley transfer
Figure 2-7 . Bridge Crane Crossover Assembly - TM-55-1930-209-14P-13_36
Figure 2-7 . Bridge Crane Crossover Assembly - TM-55-1930-209-14P-13_37
Section IV. Maintenance instructions - TM-55-1930-209-14P-13_38
Maintenance procedures - TM-55-1930-209-14P-13_39
Table 2-2. Bridge Crane Troubleshooting
Table 2-2. Bridge Crane Troubleshooting (Continued)
5-ton geared trolley hoist
Test - TM-55-1930-209-14P-13_43
Cleaning and inspection - TM-55-1930-209-14P-13_44
Electrical test and repair
Electrical test and repair - cont
Bridge Crane Trolley Brake
Figure 2-10. Bridge Crane System Schematic - TM-55-1930-209-14P-13_48
Figure 2-10. Bridge Crane System Schematic - cont
Figure 2-10. Bridge Crane System Schematic - TM-55-1930-209-14P-13_50
Cleaning and inspection - TM-55-1930-209-14P-13_51
Administrative storage - TM-55-1930-209-14P-13_52
Section VII. Manufacturers' warranties/guarantees - TM-55-1930-209-14P-13_53
CHAPTER 3 BOW CRANE SYSTEM
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_55
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_56
Figure 3-1. Bow Crane in Traveling (Stowed) Position - TM-55-1930-209-14P-13_57
Figure 3-4. Hydraulic Power Unit Motor Controller
v
Limitations
Tools and test equipment
Section III. Operating instructions - TM-55-1930-209-14P-13_62
Bow crane procedures for deploying workboat
Workboat recovery procedures
Figure 3-6. START/STOP Control Station and Anti-2-Block Control Box on Deskhouse Top
Figure 3-7. Bow Crane Base
Figure 3-8. Workboat Cradle Tie-Down with Ratchet
Bow crane shutdown procedures - TM-55-1930-209-14P-13_68
Maintenance instructions.
Maintenance procedures - TM-55-1930-209-14P-13_70
Bow crane system.
Cleaning and inspection - TM-55-1930-209-14P-13_72
Figure 3-10. Anti-2-Block Control Panel
Repair - TM-55-1930-209-14P-13_74
Cleaning and inspection - TM-55-1930-209-14P-13_75
Replacement - TM-55-1930-209-14P-13_76
Test and repair - TM-55-1930-209-14P-13_77
Replacement - TM-55-1930-209-14P-13_78
Figure 3-11. Hydraulic Power Unit Motor Controller Schematic
Hydraulic power unit
Replacement.
Section V. Storage - TM-55-1930-209-14P-13_82
Section VII. Manufacturers' warranties/guarantees - TM-55-1930-209-14P-13_83
CHAPTER 4 VOID 4 TROLLEY HOIST
Figure 4-1. Void 4 Trolley Hoist
Section III. Operating instructions - TM-55-1930-209-14P-13_86
Maintenance procedures - TM-55-1930-209-14P-13_87
Replacement - TM-55-1930-209-14P-13_88
Section V. Storage - TM-55-1930-209-14P-13_89
APPENDIX A. REFERENCE
APPENDIX A. REFERENCE - cont
APPENDIX B MANUFACTURERS' SERVICE MANUALS/INSTRUCTIONS - TM-55-1930-209-14P-13_94
HOW TO ORDER REPLACEMENT PARTS - TM-55-1930-209-14P-13_98
SPANMASTER REPLACEMENT PARTS MANUAL
RECOMMENDED PREVENTATIVE MAINTENANCE PROGRAM
Crane and Carrier Drive Machinery
OPERATION AND SAFETY RECOMMENDATIONS
TM-55-1930-209-14P-13_103
QUARTERLY INSPECTION AND SERVICE ROUTINE
SEMI-ANNUAL INSPECTION AND SERVICE ROUTINE
RECOMMENDED SPARE PARTS LIST FOR SPANMASTER EQUIPMENT
35-300 SERIES GEARCASE
CHANGE GEARS
CRANE DRIVE ASSEMBLY
END TRUCKS
END TRUCK ASSEMBLY 3400 LB. CAPACITY - HAND PROPELLED
END TRUCK ASSEMBLY 13,000 LB. CAPACITY -MOTOR DRIVEN
END TRUCK ASSEMBLY 31,000 LB. CAPACITY-MOTOR DRIVEN
TROLLEY ROCKER PRINCIPLE - TM-55-1930-209-14P-13_114
TROLLEY ROCKER PRINCIPLE - TM-55-1930-209-14P-13_115
WHEEL TROLLEY
TROLLEY TRACK FOR FESTOONE ELECTRIFICATION
ELECTRICAL CONTROL PARTS
SAMPLE BALLAST RESISTOR DIAGRAM
HORIZONTAL AND VERTICAL MOUNTING
CRANE INTERLOCK
INSTALLATION OF REEL
PARTS LIST - TM-55-1930-209-14P-13_123
POW-R-MITE 200a AND 300a
MAINSPRING AND CUP
DESCRIPTION - TM-55-1930-209-14P-13_126
MAINTENANCE AND SERVICE
Table 2. Parts List
BRAKE SPECIFICATIONS
Parts and Instruction Manual Low Headroom
DO'S AND DON'TS FOR SAFE OPERATION
INSTALLATION - TM-55-1930-209-14P-13_133
INSPECTION - TM-55-1930-209-14P-13_134
RECORD COPY
HOIST MAINTENANCE
Gear Cover Side Parts Service
LUBRICATION
Mechanism - Handwheel End - TM-55-1930-209-14P-13_139
Mechanism - Handwheel End - TM-55-1930-209-14P-13_140
Mechanism - Handwheel End - CONT - TM-55-1930-209-14P-13_141
Mechanism - Handwheel End - CONT - TM-55-1930-209-14P-13_142
Hoist Assembly
Hoist Assembly - cont - TM-55-1930-209-14P-13_144
Hoist Assembly - cont - TM-55-1930-209-14P-13_145
Hoist Assembly - cont - TM-55-1930-209-14P-13_146
Hoist Assembly - cont - TM-55-1930-209-14P-13_147
Hoist Assembly - cont - TM-55-1930-209-14P-13_148
Hoist Assembly - cont - TM-55-1930-209-14P-13_149
Bottom Block Assembly
Bottom Block Assembly - cont - TM-55-1930-209-14P-13_151
Bottom Block Assembly - cont - TM-55-1930-209-14P-13_152
Trolley Drive Assembly
INSTRUCTION, MAITENANCE and PARTS MAUAL
INSTRUCTION, MAITENANCE and PARTS MAUAL - CONT
FOREWORD
ATTACHING LOAD CHAIN
POWER SUPPLY AND ELECTRICAL CONNECTIONS
CHECKING LIMIT SWITCH OPERATION
FIGURE 5. SHORTENING CONTROL CORD
FIGURE 6. LOW HEADROOM LODESTAR TROLLEY
Enclosed Collectors and Wiring
Wheel Assembly
Track Clamp Assembly
Track Clamp Assembly - cont
IMPORTANT. NOTICE
Bulletin J CHESTER ZEPHYR LOW HEAD ROOM HOISTS
ZEPHYR LOW HEAD ROOM HOIST
FIGURE 10. ATTACHING CHAIN CONTAINER.
SECTION B - OPERATION
SECTION C- MAINTENANCE
TESTING - TM-55-1930-209-14P-13_175
Lodestar Protector
Figure 13. CUTTING LOAD CHAIN
Hoist Lubrication
Figure 14. ENCLOSED TYPE LIMIT SWITCHES
SECTION D - TROUBLE SHOOTING
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_181
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_182
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_183
SECTION D - TROUBLE SHOOTING - CONT - TM-55-1930-209-14P-13_184
Wiring Diagrams shown are representative
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_186
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_187
Wiring Diagrams shown are representative - cont - TM-55-1930-209-14P-13_188
SECTION E - REPLACEMENT PARTS LIST
FIGURE 18. CENTRIFUGAL MECHANISM ASSEMBLY
Lodestar Hoist - exploded view - TM-55-1930-209-14P-13_191
Parts List - TM-55-1930-209-14P-13_192
Lodestar Hoist - exploded view - TM-55-1930-209-14P-13_193
Parts List - TM-55-1930-209-14P-13_194
CONTROL STATION
CONTROL STATION USED ON MODELS A THRU H, THREE PHASE AND SINGLE PHASE WITH CONTACTOR, AND MODELS J THRU RR, ALL VOLTAGES
CHAIN CONTAINER
LOW HAEDROOM LODESTAR TROLLEY
ENCLOSED CONDUCTOR SYSTEM CURRENT COLLECTORS
SECTION F-NON-CURRENT PARTS
SECTION F-NON-CURRENT PARTS - cont
Parts List MODELS J, L & R
Type AB CONTRACTOR - Parts List
PUSH BUTTONS SWITCHES
SERIES D PUSH BUTTONS STATION
SERIES E PUSH BUTTONS STATION
MOTOR DRIVEN TROLLEY
MOTOR DRIVEN TROLLEY - PARTS LIST
LOW HEADROOM LODESTAR TROLLEY
Adjustment of Open Type Limit Switch
CURRENT COLECTORS
COLLECTOR ASSEMBLY PARTS LIST
OPERATING AND USE OF THE CRANE
USE OF ACCESSORIES
PERIODIC MAINTENANCE INSTRUCTIONS
PILLAR AND BASE ASSEMBLY
OUTRIGGER RAMS ASSEMBLY
OUTRIGGER EXTENSION RAMS
OUTRIGGER RAMS
DEVIATOR AND DISTRIBUTO ASSEMBLY WITH DOUBLE CONTROLS
DISTRIBUTORS
PIPING FOR OUTRIGGER EXTENTION RAMS
PIPING FOR OUTRIGGER RAMS
PIPING FOR ROTATION
PIPING FOR ROTATION - CONT
EXTENSION BOOMS ASSEMBLY FOR FIO.2
EXTENSION BOOMS AND MAIN JIB ASSEMBLY FOR FIO.2
EXTENSION BOOMS ASSEMBLY FOR FIO.3
EXTENSION BOOMS AND MAIN JIB ASSEMBLY FOR FIO.3
DOUBLE EXTENSION RAM
TRIPLE EXTENSION RAM
PIPING FOR MAIN RAMS (TYPE A)
PIPING FOR MAIN RAMS (TYPE B)
PIPING FOR SECONDARY RAM
PIPING FOR BOOMS EXTENSION RAM
OIL TANK ASSEMBLY
RETURN PIPINGS ASSEMBLY
PILLAR AND BASE ASSEMBLY - CRANE WITH SEAT
DEVIATOR AND DISTRIBUTION ASSEMBLY - CRANE WITH SEAT
DISTRIBUTOR FOR OUTRIGGER - CRANE WITH SEAT
SEAT AND DISTRIBUTION ASSEMBLY ON PILLAR
PIPING FOR DISTRIBUTOR - CRANE WITH SEAT
EXTENSIONS M AND MN FOR FIO.3
EXTENSION MNP FOR FIO.3
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_257
CONTROL PANEL TERMINAL
ANTI - TWO - BLOCK
ANTI - TWO - BLOCK - CONT
INSTALLATION PROCEDURE
CHECKOUT PROCEDURE
BOOM NOSE CONNECTOR
SCHEMATIC DIAGRAM
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_269
SCHEMATIC DIAGRAM - TM-55-1930-209-14P-13_270
Troubleshooting - TM-55-1930-209-14P-13_271
Troubleshooting - cont - TM-55-1930-209-14P-13_272
Troubleshooting - cont - TM-55-1930-209-14P-13_273
Troubleshooting - cont - TM-55-1930-209-14P-13_274
Troubleshooting - cont - TM-55-1930-209-14P-13_275
Troubleshooting - cont - TM-55-1930-209-14P-13_276
Troubleshooting - cont - TM-55-1930-209-14P-13_277
Troubleshooting - cont - TM-55-1930-209-14P-13_278
Troubleshooting - cont - TM-55-1930-209-14P-13_279
Troubleshooting - cont - TM-55-1930-209-14P-13_280
Troubleshooting - cont - TM-55-1930-209-14P-13_281
REPAIR PARTS LIST - TM-55-1930-209-14P-13_290
REPAIR PARTS LIST - TM-55-1930-209-14P-13_291
REPAIR PARTS LIST - TM-55-1930-209-14P-13_292
REPAIR PARTS LIST - TM-55-1930-209-14P-13_293
REPAIR PARTS LIST - TM-55-1930-209-14P-13_294
REPAIR PARTS LIST - TM-55-1930-209-14P-13_295
APPENDIX C Preventive maintenance checks and services (PMCS) - TM-55-1930-209-14P-13_296
Introduction to PMCS - TM-55-1930-209-14P-13_297
Handling equipment description
APPENDIX C Preventive maintenance checks and services (PMCS) - TM-55-1930-209-14P-13_299
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_300
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_301
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_302
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_303
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_304
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_305
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_306
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_307
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_308
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_309
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_310
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_311
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_312
Table C-1. Preventive Maintenance Checks and Services - (Continued) - TM-55-1930-209-14P-13_313
