TM 5-4610-233-13&P
WARNING
Hypochlorite solution is toxic to skin and eyes. Avoid
repeated or prolonged contact, Wear skin and eye
protection to prevent personal injury.
f. Remove reservoir fill tube from reservoir tank.
g. Disconnect and remove liquid head assembly suction and discharge tubes.
h. Remove reservoir tank from hypochlorination unit. Dispose of remaining solution in reservoir tank
according to TM 3-250.
i.
Install reservoir tank on hypochlorination unit.
WARNING
Hypochlorination unit weighs 241 pounds (109.3 kg). At
least four people are needed to lift it to prevent personal
injury or damage to the equipment.
NOTE
Flow controller drain cock must remain open during
movement.
j .
Tip hypochlorination unit and turn flow controller drain cock open (counterclockwise).
k. Open inlet shutoff cock, outlet shutoff cock, and hypochlorite solution shutoff cock.
WARNING
Hypochlorination unit weighs 241 pounds (1 09.3 kg). At
least four people are needed to lift it to prevent personal
injury or damage to the equipment.
l. Tip hypochlorination unit from side to side to drain water from hoses, tubes, and components.
m. Install reservoir fill tube, liquid head assembly washers, and suction and discharge tubes.
n. Install suction tube and washer to bottom of liquid pump.
o. Install discharge tube and washer to top of liquid pump.
p. Set range adjusting valve to fully open position (parallel to manifold) and secure with quick-release pin.
2-8. OPERATING INSTRUCTIONS ON DECALS AND INSTRUCTION PLATES. The hypochlorination unit
instruction plate is located on the frame supporting the reservoir tank assembly. See figure 2-3.
2-10
