ARMY TM 10-4610-309-14
MARINE CORPS TM 10802A-14/1
TACTICAL WATER PURIFICATION SYSTEM (TWPS)
0015 00
OPERATOR INSTRUCTIONS
START-UP AFTER A SHORT TERM OR STANDBY SHUTDOWN
WITHOUT DRAINING OPERATION UNDER USUAL CONDITIONS
ADAPTOR A-01
CHECK VALVE
RAW WATER FLOW
VENT VALVE V-102
CONTROL VALVE V-107
CYCLONE BLOWDOWN
FLOW VALVE V-104
DRAIN VALVE V-103
AND
DRAIN VALVE V-105
Figure 3. Raw Water System with Both Raw Water Pumps.
WARNING
Combustion hazard. Fuel the diesel engine in a well ventilated area with the engine
stopped. Do not smoke or allow flames or sparks in the area where the engine is fueled or
where the fuel is stored. Failure to observe this warning may result in fire and severe
injury.
Combustion hazard. Do not overfill the fuel tank. Make sure the filler cap is securely
closed after fueling. Be careful not to spill fuel when fueling. If any fuel is spilled, make
sure the area is dry before starting the engine. Failure to observe this warning may result
in fire and severe injury.
CAUTION
Potential for engine damage. The diesel engine may be damaged if operated with
insufficient lube oil. It is also dangerous to supply too much lube oil to the engine
because a sudden increase in engine rpm could be caused by its combustion. Failure to
observe this caution may result in engine damage.
Potential for engine damage. Only use the correct diesel fuel. Use of the wrong fuel may
cause engine damage.
When adding fuel to the fuel tank, be careful not to push the fuel screen filter into the tank.
4. Before starting the diesel-driven pump, the diesel fuel tank may be topped off. For short term
shutdown, there is no need to check the oil level.
5. Start the diesel engine using the following procedure (see Figure 4).
a. Set the fuel cock clockwise to the OPEN position.
0015 00-5
