TM 5-3800-205-10-2
TROUBLESHOOTING PROCEDURES - CONTINUED
0011 00
Table 2. Transport Mode Troubleshooting Procedures - Continued.
MALFUNCTION
TEST OR INSPECTION
CORRECTIVE ACTION
CH-47 HELICOPTER TRANSPORT - CONTINUED
Reconnect
electrical
con-
11. Taillights Do Not Come On (After
Check electrical connectors on
nections, if required. If problem
Machine Assembly).
right side of draft frame for loose
still exists, refer to ELECTRI-
connections.
CAL SYSTEM troubleshooting
Reconnect hydraulic hoses, if
12. Tank Operation is Erratic, After
Check hydraulic hoses at draft
required. If problem still exists,
Reconnection of Lift Cylinders.
frame for loose connections (WP
refer to WATER DISTRIBU-
TOR SYSTEM troubleshooting
13. Windshield Washer Inoperative (After
1. Check that fluid hose is
1. Install fluid hose, if required. If
installed (WP 0016 00).
problem still exists, go to test
Machine Assembly).
step 2.
2. Check fluid reservoir inside
2. If reservoir is empty, fill
engine compartment.
reservoir (WP 0013 00). If
problem still exists, go to test
step 3.
3. Check for blown fuse.
3. If fuse is bad, request a
replacement fuse from Unit
Maintenance. If fuse is good,
refer
to
ELECTRICAL
SYSTEM
troubleshooting
14. Windshield Wiper Motor Inoperative
1. Check wiper motor electrical
1. Reconnect electrical con-
connectors
for
loose
nectors, if required. If problem
(After Machine Assembly).
connections.
still exists, go to test step 2.
2. Check for blown fuse.
2. If fuse is bad, request a
replacement fuse from Unit
Maintenance. If fuse is good,
refer
to
ELECTRICAL
SYSTEM
troubleshooting
Check that pivot and drive shaft
Tighten pivot and drive shaft
15. Windshield Wiper Motor Operates But
nuts are tight (WP 0016 00).
nuts, if required. If problem still
Wiper Arm Will Not Move (After
exists, notify Unit Maintenance.
Machine Assembly).
END OF WORK PACKAGE
